Boeing 720


The Boeing 720 is a narrow-body airliner produced by Boeing Commercial Airplanes.
Announced in July 1957 as a 707 derivative for shorter flights from shorter runways, the 720 first flew on November 23, 1959.
Its type certificate was issued on June 30, 1960, and it entered service with United Airlines on July 5, 1960.
A total of 154 Boeing 720s and 720Bs were built until 1967.
As a derivative, the 720 had low development costs, allowing profitability despite few sales.
Compared to the 707-120, it has a length reduced by 9 feet, a modified wing and a lightened airframe for a lower maximum takeoff weight.
Powered by four Pratt & Whitney JT3C turbojets, the initial 720 could cover a range with 131 passengers in two classes.
Powered by JT3D turbofans, the 720B first flew on October 6, 1960, and entered service in March 1961.
It could seat 156 passengers in one class over a range, some 720s were later converted to 720B specification.
It was succeeded by the Boeing 727 trijet.
The 720 is the only Boeing jetliner not following the "7x7" naming scheme, excluding former McDonnell Douglas airliners.

Development

Shorter range 707

Boeing announced its plans to develop a new version of the 707 in July 1957. It was developed from the to provide for short- to medium-range flights from shorter runways. The model was originally designated 707-020 before being changed to 720 at the input of United Airlines. Compared to the, it has four fewer frames in front of the wing and one fewer aft: a total length reduction of.
The new model was designed to a lower maximum takeoff weight with a modified wing and a lightened airframe. The wing modifications included Krueger flaps outboard of the outboard engines, lowering take-off and landing speeds—thus shortening runway length requirements—and a thickened inboard leading edge section, with a slightly greater sweep. This modification increased the top speed over the. It had four Pratt & Whitney JT3C-7 turbojet engines producing each.
At one point in the development phase, it was known as the, then, although this was the Boeing model designation of the KC-135 and remained unused for a commercial airliner until it was applied to the MD-95, following Boeing's merger with McDonnell Douglas in 1997.
Because the aircraft systems were similar to the Boeing 707, no prototype Boeing 720 was built; any different systems were tested on the Boeing 367-80. The first 720 took its maiden flight on November 23, 1959. The type certificate for the 720 was issued on June 30, 1960. It was first entered service with United Airlines on July 5, 1960; 65 of the original version were built.

Further developments

The 720B version of the 720 had JT3D turbofan engines, producing each. The JT3D engines had lower fuel consumption and higher thrust. The maximum takeoff weight for the 720B was increased to. The 720B first took to the skies on October 6, 1960, and received certification and entered service with American Airlines in March 1961; 89 720Bs were built, in addition to conversions of American's 10 existing 720s.
As a modification of an existing model, the 720 had minimal research and development costs, which allowed it to be successful despite few sales. The company built 154 Boeing 720s and 720Bs from 1959 to 1967. The 720's wing modification was later added on the 707-120B and on 707-120s retrofitted to the B standard.

Design

The Boeing 720 is a four-engined low-wing cantilever monoplane. Although it was similar to the Boeing 707, compared with the, it was shorter in length, and had a lighter structure through use of lighter forged metal parts and thinner fuselage skins and structures.

Fuselage

The rearmost of the 707's over-wing emergency exits was deleted on each side, which reduced passenger capacity, while two over-wing exits were an option for higher-density configurations.

Wings

The 720 uses an improved wing based on the 707 wing. The wingspan remained the same as the. For the 720, the wing was changed between the fuselage and inner engines by adding a wing root glove. This glove reduced the drag of the wing by decambering the root, which reduced the "middle effect", thereby increasing the effective local wing sweep. The wing root glove reportedly increased the drag divergence Mach number of the wing by Mach 0.02.

Engines

Though initially fitted with turbojet engines, the dominant engine for the Boeing 720 was the Pratt & Whitney JT3D, a turbofan variant of the JT3C with lower fuel consumption and higher thrust. JT3D-engined 720s had a "B" suffix; some of American's 720Bs were conversions of JT3C-powered 720s.
Like the 707, the 720/720B used engine-driven turbocompressors to supply high-pressure air for cabin pressurization. The engines could not supply sufficient bleed air for this purpose without a serious loss of thrust. The small air inlets and associated humps are visible just above the main engine inlets on the two inner engine pods of all 720s and 720Bs; the lack of the turbocompressor inlet on the outer starboard pod helps spotters distinguish 720/720Bs from most 707s, which had three turbocompressors.

Other equipment

The Boeing 720 lacked an auxiliary power unit, and relied instead on ground power and pneumatic air to power the aircraft's systems, provide air conditioning, and start the engines while on the ground. The normal practice for Boeing 720 aircraft was to start the number three engine first, then disconnect ground power and air. After start of the first engine, the use of bleed air from that engine could be used to provide necessary air pressure to start the other engines one by one. However, on ground, with ground starting crew already at hand, all four engines were usually started with ground crew help, as this was more reliable and faster.

Operational history

The first aircraft was a production aircraft for United Airlines which flew on November 23, 1959. The type certificate for the 720 was issued on June 30, 1960. The first service of the 720 was by United Airlines on July 5, 1960 on the Los Angeles-Denver-Chicago route. American Airlines followed by putting the 720 in commercial operation on July 31 that same year. On January 2, 1962, Pakistan International Airlines′ first Boeing 720B – a Boeing 720-040B piloted by Captain Abdullah Baig and copilot Captain Taimur Baig – set a world record during the London-to-Karachi leg of its delivery flight to Pakistan for speed over a commercial air route, making the flight in 6 hours 43 minutes 55 seconds at an average speed of.
The 720 was supplanted by the Boeing 727 in the mid-1960s in its medium-range, high-performance market. In the late 1960s, 720 and 720B aircraft were used by the US military to shuttle troops to the Far-East war efforts. The interiors of these planes were stripped of class partitions. Some of these flights originated at Travis AFB California and flew nonstop to Japan. At least one of the landing sites was Yokota AB, Japan, before the troops traveled to their final destinations.
After disposal of 720s by the major airlines, many were acquired by second-rank operators in South America and elsewhere.
used a FAA 720
In 1984, a Boeing 720 flown by remote control was intentionally crashed at Edwards AFB as a part of the FAA and NASA Controlled Impact Demonstration program. The test provided peak accelerations during a crash. The performance of fire-retardant fuel was also tested.
The first 720 was later renamed "The Starship" and became a private charter jet used mainly by touring rock bands. Its main user was Led Zeppelin in the 1970s. The seating capacity was reduced and a bar with a built-in electric organ was added, along with beds, a shower, a lounge area, a TV, and video cassette player.
Honeywell operated the last Boeing 720 in the United States, flying out of Sky Harbor airport in Phoenix. The aircraft had been modified with an extra engine nacelle mounted on the right side of the fuselage to allow testing of a turbine engine at altitude, operating on special certification allowing it to be used for experimental use. This 720B was scrapped on June 21 and 22, 2008. Honeywell replaced their aircraft with a Boeing 757.
Pratt & Whitney Canada operated the last flying 720 until 2010. Its final operational flight occurred on September 29, 2010. Pratt & Whitney Canada replaced the testbed with a Boeing 747SP. In May 2012, the former PWC 720 was flown to CFB Trenton, Ontario, to be put on display at the National Air Force Museum of Canada.

Variants

;720
;720B

Operators

These operators flew Boeing 720/720Bs :

Accidents and incidents

The Boeing 720 has had 23 hull-loss accidents during its career; it was also involved in a number of incidents including nine hijack incidents and one aircraft destroyed by a bomb in mid-air in 1976. Only 12 of the hull-loss accidents included fatalities which totaled 175 deaths in addition to the 81 deaths on the aircraft destroyed in mid-air by a bomb.
The worst accidents were: