Cessna 177 Cardinal


The Cessna 177 Cardinal is a light single-engine, high-wing general aviation aircraft that was intended to replace Cessna's 172 Skyhawk. First announced in 1967, it was produced from 1968 to 1978.

Development

The Cessna 177 was designed in the mid-1960s when the engineers at Cessna were asked to create a "futuristic 1970s successor to the Cessna 172". The resulting aircraft featured newer technology such as a cantilever wing lacking the lift struts of previous models, and a new laminar flow airfoil. The 177 is the only production high-wing single-engined Cessna since the Cessna 190 & 195 series to have both fixed landing gear and a cantilever wing without strut bracing.
In 1971, Cessna experimented with a "Quiet Cardinal" similar to the Beechcraft QU-22 Pave Eagle. A test model was flown with a Wankel engine with a large three bladed 100 inch diameter propeller with a belt driven gear reduction unit and a fuselage-length exhaust canted upward.
The 1968 model 177 was introduced in late 1967 with a 150 hp engine. One of the design goals of this 172 replacement was to allow the pilot an unobstructed view when making a turn. In the 172 the pilot sits under the wing and when the wing is lowered to begin a turn that wing blocks the pilot's view of where the turn will lead to. The engineers resolved this problem by placing the pilot forward of the wing's leading edge, but that led to a too-far-forward center of gravity.
This problem was partially counteracted by the decision to use the significantly lighter Lycoming O-320 four-cylinder engine in place of the six-cylinder O-300 Continental used on the 172. The forward CG situation still existed even with the lighter engine, so a stabilator was chosen, to provide sufficient elevator control authority at low airspeeds.
The 177 design was intended to be a replacement for the 172, which was to be discontinued after introduction of the new aircraft. The new design was originally to be called the 172J. However, as the time came to make the transition, there was considerable resistance to the replacement of the 172 from the company's Marketing Division. The 1969 172 jumped to the designator 172K—there is no 172J.
The 177 offers much better upward visibility than a 172 because of its steeply raked windshield and more aft-mounted wing. The absence of an obstructing wing support strut also makes the aircraft an excellent platform for aerial photography.

Performance and handling problems

Soon after delivery of the first Cardinals to customers there were reported incidents of pilot-induced oscillation that alarmed Cessna enough that the factory initiated a priority program to eliminate the problem. Reviewer Joe Christy explains:
The solution, which was provided to all aircraft already delivered at no cost, was known as Operation "Cardinal Rule" and included a series of 23 inspection, installation, and modification instructions. This Service Letter, SE68-14, consisted of modifying the stabilator to install slots just behind the leading edge and installing full counterbalance on the stabilator to eliminate the PIO problem.
The 177, with its 150 hp powerplant, was considered "underpowered", even though it had more power than the 145 hp Cessna 172.

Cessna 177A

Recognizing that the aircraft was underpowered, Cessna introduced the 177A in 1969. The revision featured a 180 hp four-cylinder Lycoming O-360, moving the design's price and role somewhere between that of the 172 and 182. The additional power improved cruise speed by 11 knots.

Cessna 177B

1970 saw the introduction of the 177B, which had a new wing airfoil, a constant-speed propeller, and other minor improvements. When empty, the 177B weighed 145 lb more than the earlier 177, with its maximum takeoff weight increased from 2,350 lb to 2,500 lb.
In 1978, Cessna built a deluxe version of the 177B, the Cardinal Classic, with leather upholstery, a table for the rear passengers, and a 28-Volt electrical system.

Cessna 177RG

The final aircraft in the 177 line was the retractable-gear 177RG Cardinal RG, which Cessna began producing in 1971 as a direct competitor to the Piper PA-28R-200 Cherokee Arrow and Beechcraft Sierra. The nose gear folds rearward; when opened the gear door formed a small air brake behind the propeller.
To offset the increase in empty weight, much of which was from the electrically powered hydraulic gear mechanism, the 177RG had a Lycoming IO-360 engine. This also allowed increase of the maximum weight by 300 lbs.
The additional power and cleaner lines of the 177RG resulted in a cruise speed of, faster than the 177B. 1,543 177RGs were delivered between the US and Reims, Cessna's licensed partner in France. Those built in France by Reims were referred to as the Reims F177RG.

Notable accidents and incidents