Charomskiy ACh-30


The Charomskiy ACh-30 was a Soviet aircraft diesel engine developed during World War II. The initial version was not very satisfactory and it was cancelled when its factory was forced to evacuate in the autumn of 1941. Production was reinitiated in the summer of 1942 and continued until September 1945 to meet the need for an economical engine to power the Soviet long-range bombers like the Petlyakov Pe-8 and the Yermolayev Yer-2.

Development

The ACh-30 was a development of the experimental AN-1RTK turbo-supercharged diesel engine that had begun development in the early 1930s. It was initially designated as the AD-5 when development began in the sharashka attached to Factory No. 82 at Tushino Airport in 1939. Construction of the first five prototypes began at the end of that year and it passed its tests in early 1940. Preparations to begin series manufacture at Factory No. 82 began in May 1940, but actual production was delayed until 1941 when forty-four were built as the M-30. Production was planned to be transferred to the Kharkov Tractor Factory, but this was cancelled before any engines were built. The M-30 had proven to be unsatisfactory in service, as it was unreliable and troublesome at high altitudes and in cold conditions. Specific problems were its failure to deliver full rpm and it suffered from oil blowouts and failures of the oil pumps. Therefore, production was cancelled when Factory No. 82 was forced to evacuate in the fall of 1941 because of the German advance on Moscow.
Production was reinitiated in the evacuated workshops of Factory No. 82 by Factory No. 500 in June 1942, thirty-two engines being completed during the year. Development of supercharged versions began about the same time, using geared, centrifugal type superchargers adapted from the Mikulin AM-38 and the Klimov M-105 engines with intercoolers. That from the AM-38 was more successful and was put into production as the M-30B. Thirty-five incomplete M-30 engines were modified beginning in August into M-30Bs and then thirty-four M-30Bs were produced during the rest of 1942. Oddly the ACh-30B, as the engine was now known, was not formally accepted for series production until 19 June 1943, but production had begun quite a bit earlier than that. Factory No. 45 began production in the fourth quarter of 1943. Some 1450 ACh-30Bs were built before production ended at both factories in September 1945.
The ACh-30B was tested as a motorjet where the jet engine's compressor was driven by an incorporated piston engine. It was bench tested from June 1944 through May 1945, but was never installed in any aircraft. The jet engine's thrust was and the equivalent horsepower of the combination was. The combination weighed.
Versions of the ACh-30 were evaluated on the Ilyushin Il-6 and the ANT-67, a long-range version of the Tupolev Tu-2, but neither aircraft was put into production. It was also proposed for use on the Tupolev Tu-8S and the MN executive transport, but neither of those projects progressed past design proposal stage.

Variants