The Hercules was designed as a lightweight single-seat aircraft, with a second seat available to carry an instructor or passenger when required. Because it was intended to be flown solo most of the time it came factory-supplied with a relatively low powered engine, to reduce both the aircraft's cost and weight. Higher powered engines were available if the aircraft was to be used in the training role on a regular basis. In writing about the Hercules, reviewer Andre Cliche explained the engine choice, "Because most people usually fly alone in their two-seater, it makes for a well balanced single seater with peppy performance, low fuel burn and longer range. However, when comes the time to carry an occasional passenger, its two-seater capacity far outweighs its anemic performance with two people aboard. This is a smart compromise that gives the best of both worlds." The Hercules was designed to comply with the US FAR 103 Ultralight Vehicles rules when flown as a single-seater, including the category's maximum empty weight of. The aircraft has a standard empty weight of. It features a cable-braced hang glider-style high-wing, weight-shift controls, a two-seats-in-tandem open cockpit, tricycle landing gear and a single engine in pusher configuration. The aircraft is made from bolted-together aluminumtubing, with its single surface wing covered in Dacron sailcloth. Its span wing is supported by a single tube-type kingpost and uses an "A" frame control bar. The standard wing supplied was the Mustang double-surface wing of. A smaller wing of was available to increasecruising speed at the cost of a higher stall speed. The aircraft has an acceptable installed power range of. The standard engine supplied was the twin cylinder two-stroke2si 460-F35, with the Rotax 503 or the Rotax 582 engines available as options. Other engines used include the Cuyuna UL II-02, Rotax 447, Rotax 618 and the four-strokeHKS 700E. Due to its off-airport capabilities the Hercules was nicknamed "the jeep of trikes". It is noted for its ease of set-up and repair. Twenty-five had been completed and flown by February 2000.
