The GBU-39/B Small Diameter Bomb is a precision-guidedglide bomb that is intended to provide aircraft with the ability to carry a higher number of more accurate bombs. Most US Air Force aircraft will be able to carry a pack of four SDBs in place of a single bomb. The Small Diameter Bomb II / GBU-53/B, adds a tri-mode seeker to the INS and GPS guidance of the original SDB.
Description
The original SDB is equipped with a GPS-aidedinertial navigation system to attack fixed/stationary targets such as fuel depots, bunkers, etc. The second variant will include a thermal seeker and radar with automatic target recognition features for striking mobile targets such as tanks, vehicles, and mobile command posts. The small size of the bomb allows a single strike aircraft to carry more of the munitions than is possible using currently available bomb units. The SDB carries approximately of AFX-757 high explosive. It also has integrated "DiamondBack" type wings which deploy after release, increasing the glide time and therefore the maximum range. Its size and accuracy allow for an effective munition with less collateral damage. Warhead penetration is of steel reinforced concrete under of earth and the fuze has electronic safe and fire cockpit selectable functions, including air burst and delayed options. The SDB I has a circular error probable of. CEP is reduced by updating differential GPS offsets prior to weapon release. These offsets are calculated using an SDB Accuracy Support Infrastructure, consisting of three or more GPS receivers at fixed locations transmitting calculated location to a correlation station at the theatre Air Operations Center. The corrections are then transmitted by Link 16 to SDB-equipped aircraft.
Alternative guidance and warheads
In November 2014, the U.S. Air Force began development of a version of the SDB I intended to track and attack sources of electronic warfare jamming directed to disrupt the munitions' guidance. The home-on-GPS jam seeker works similar to the AGM-88 HARM to follow the source of a radio-frequency jammer to destroy it. In January 2016, the Air Force awarded a contract to Scientific Systems Co. Inc. to demonstrate the company's ImageNav technology, a vision-based navigation and precision targeting system that compares a terrain database with the host platform's sensor to make course corrections. ImageNav technology has demonstrated target geo-location and navigation precision greater than three meters. In January 2016, Orbital ATK revealed that the Alternative Warhead, designed for the M270's GMLRS to achieve area effects without leaving behind unexploded ordnance, had been successfully tested on the SDB.
Development
In 2002, while Boeing and Lockheed Martin were competing to develop the Small Diameter Bomb, Darleen A. Druyun—at that time Principal Deputy Assistant Secretary of the Air Force for Acquisition and Management—deleted the requirement for moving target engagement, which favored Boeing. She was later convicted of violating a conflict of interest statute. On May 1, 2009, Raytheon announced that it had completed its first test flight of the GBU-53/B Small Diameter Bomb II, which has a data link and a tri-mode seeker built with technology developed for the Precision Attack Missile. And on August 10, 2010 the U.S. Air Force awarded a $450 million contract for engineering and development. Although unit costs were somewhat uncertain as of 2006, the estimated cost for the INS/GPS version was around US$70,000. Boeing and the Italian firm Oto Melara have signed a contract covering the license production of 500 GBU-39/B and 50 BRU-61/A racks for the Aeronautica Militare, at a cost of nearly US$34 million. US$317m was spent on R&D and spares for SDB II in FY13/14, with US$148.5m requested in these categories for FY15, the total budget split roughly 70:30 between USAF and USN. SDB II production began in FY14 with 144 bombs for the USAF at a unit cost of US$250,000. The FY15 budget requested 246 bombs at a cost of US$287,000 each. When the Pentagon approved the SDB II for production and deployment in May 2015, it had a unit cost of.
Timeline
October 2001 – Boeing is awarded the SDB contract.
September 2005 – Small Diameter Bomb certified for operational test, evaluation.
September 2006 – SDB team deliver the first SDBs to the USAF.
Under a contract awarded in September 2006, Boeing developed a version of the SDB I which replaces the steel casing with a lightweight composite casing and the warhead with a focused-blast explosive such as Dense Inert Metal Explosive. This should further reduce collateral damage when using the weapon for pin-point strikes in urban areas. On 28 February 2008, Boeing celebrated the delivery of the first 50 FLM weapons. The USAF intends to use the same FLM casing on a weapon of. In December 2013, Boeing delivered the last of the 500 FLMs under contract.
GBU-39B/B – Laser SDB
In mid-2012, the U.S. Senate recommended zeroing out funding for the SDB II due to fielding delays with the F-35 Lightning II. With the delay in SDB II fielding, Boeing recommended an upgrade to their SDB as a temporary gap-filler to get desired performance at a fraction of the cost. Called the Laser Small Diameter Bomb, it integrates the laser used on the JDAM to enable the bomb to strike moving targets. Boeing began testing the LSDB in 2011 and successfully hit targets traveling. In June 2013, the Air Force announced it would award Boeing a contract to develop and test the LSDB; the contract is for phase one part two engineering, integration and test, and production support and an LSDB Weapon Simulator. Boeing says the LSDB can be built at a lower cost than the planned Raytheon SDB II, as it will use the same semi-active laser sensor as the JDAM to hit moving and maritime targets. However, Boeing admits that it does not have the capability to engage targets in zero-visibility weather, as it lacks the SDB II's millimeter wave radar. The Laser SDB began fielding with the U.S. Special Operations Command in 2014.
Ground Launched Small Diameter Bomb (GLSDB)
Boeing and Saab Group have modified the Small Diameter Bomb with a rocket motor to be launched from ground-based missile systems such as the M270 MLRS. With the Army demilitarizing cluster munitions from M26 rockets, the company says a special adapter case could reuse the rocket to launch the SDB. After the motor launches it to a high enough altitude and speed, the wings will deploy and glide the bomb to its target. The company believes it can fill a gap for long-range precision fires while using its smaller warhead to save larger rocket munitions for strategic targets. While typical MLRS systems follow a ballistic trajectory, the rocket-launched SDB can be launched to an altitude and glide on a selected trajectory. Boeing and Saab Group conducted three successful GLSDB tests in February 2015. The system is cost-effective, utilizing an existing weapon paired with a stockpiled rocket motor, while maintaining the loadout on a rocket artillery system. Unlike other artillery weapons, the GLSDB offers 360-degree coverage for high and lowangles of attack, flying around terrain to hit targets on the back of mountains, or circling back around to a target behind the launch vehicle. The GLSDB has a range of, and can also hit targets behind it. In a 2017 demonstration, the GLSDB engaged a moving target at a distance of 100 km. The SDB and rocket motor separated at altitude and the bomb used an SAL seeker to track and engage the target. A 2019 test extended this range to 130 km against a target at sea.
