Indonesia AirAsia Flight 8501


Indonesia AirAsia Flight 8501 was a scheduled international passenger flight operated by Indonesia AirAsia – an AirAsia Group affiliate – from Surabaya, Indonesia, to Singapore. On 28 December 2014, the Airbus A320 flying the route crashed into the Java Sea, killing all 162 people on board. When search operations ended in March 2015, only 106 bodies had been recovered.
In December 2015, the Indonesian National Transportation Safety Committee released a report concluding that a non-critical malfunction in the rudder control system prompted the captain to perform a non-standard reset of the on-board flight control computers. Control of the aircraft was subsequently lost, resulting in a stall and uncontrolled descent into the sea. Miscommunication between the two pilots was cited as a contributing factor.

History of the flight

Flight 8501 was a scheduled flight from Surabaya, Java, Indonesia to Singapore on Sunday, 2014. It was scheduled to depart Juanda International Airport at 05:20 Western Indonesian Time and arrive at Singapore Changi Airport at 08:30 Singapore Standard Time. Flight 8501 took off at 05:35. Indonesia AirAsia did not have permission from the Indonesian Ministry of Transportation to operate the route on Sundays.
After departure, Flight 8501 was in contact with the Jakarta Area Control Centre, which provides air traffic control service over the western Java Sea, and flying along air route M635, when it approached a line of thunderstorms off the southwest coast of Borneo. At 06:12, Flight 8501 was flying at flight level 320—approximately —when the flight crew requested and was authorised to deviate left from its original flight path to avoid these storms. The pilot then requested to climb to flight level 380, which was deferred by ATC because of other aircraft in the vicinity. AirNav Indonesia, which operates the Jakarta Area Control Centre, reported that Jakarta Centre then cleared Flight 8501 to flight level 340 at 06:14, but no response was received; other aircraft in the vicinity were asked to contact Flight 8501, but also did not receive a response.
Between 06:17:00 and 06:17:54, the aircraft climbed from, exceeding a climb rate of 10,000 feet per minute. The flight data recorder, showed the aircraft at 35,500 feet —and still climbing—at, which is below the stall speed for the airplane's weight at that altitude. The Indonesian Minister of Transport interpreted the apparent aircraft behaviour at peak altitude as an aerodynamic stall, when it began to descend at 06:17:54, descending within six seconds and within 31 seconds. The aircraft also began a turn to the left, forming at least one complete circle before disappearing from radar at 06:18:44. Its last recorded position was over the Java Sea, Karimata Strait between the islands of Belitung and Kalimantan. The aircraft crashed in the Java Sea, Karimata Strait between the islands of Belitung and Borneo. The cockpit voice recorder captured multiple warnings, including a stall warning, sounding in the cockpit during the final minutes of the flight. No distress signal was sent from the aircraft. Search and rescue operations were activated by the Indonesia National Search and Rescue Agency from the Pangkal Pinang office.

Aircraft

The aircraft was an Airbus A320-216, with serial number 3648, registered as PK-AXC. It first flew on 2008, and was delivered to AirAsia on 2008. The aircraft was 6 years old and had accumulated approximately 23,000 flight hours over 13,600 flights. It had undergone its most recent scheduled maintenance on 2014. The aircraft was powered by two CFM International CFM56-5B6 engines and was configured to carry 180 passengers.

Victims

AirAsia released details of the 155 passengers which included 137 adults, 17 children, and one infant. The crew consisted of two pilots and four flight attendants. A company engineer was also on board and was not counted as one of the passengers.
The pilots on board the flight were:
Forty-one people who were on board the AirAsia flight were members of a single church congregation in Surabaya. Most were families with young children travelling to Singapore for a new year's holiday.
The bodies began to be returned to their families on 1 January 2015. At that time, the East Java Regional Police Department's Disaster Victim Identification commissioner stated that the victims were identified by the means of post mortem results, thumb prints, and their personal belongings.

Search and recovery

Shortly after the aircraft was confirmed to be missing, unconfirmed reports stated that wreckage had been found off the island of Belitung in Indonesia. Indonesia's National Search and Rescue Agency deployed seven ships and two helicopters to search the shores of Belitung and Kalimantan. The Indonesian Navy and the provincial Indonesian National Police Air and Water Unit each sent out search and rescue teams. In addition, an Indonesian Air Force Boeing 737 reconnaissance aircraft was dispatched to the last known location of the airliner.
The Indonesian Navy dispatched four ships by the end of the first search day and the Air Force deployed aircraft including a CASA/IPTN CN-235. The Indonesian Army deployed ground troops to search the shores and mountains of adjacent islands. Local fishermen also participated in the search.
Ongoing search and rescue operations were under the guidance of the Civil Aviation Authority of Indonesia. The search was suspended at 7:45 pm local time on due to darkness and bad weather, to be resumed in daylight. An operations center to coordinate search efforts was set up in Pangkal Pinang. The search area was a radius near Belitung Island.
Search and rescue operations quickly became an international effort. By naval and air units from Singapore, Malaysia and Australia had joined Indonesian authorities in patrolling designated search areas. Singapore's Rescue Coordination Centre deployed three C-130 Hercules aircraft to aid in the search and rescue operation. A Formidable-class frigate, a Victory-class corvette, a Landing Ship Tank, and a submarine support and rescue vessel subsequently took part in the search and rescue after Indonesia's National Search and Rescue Agency accepted the offer of help from the Republic of Singapore Navy. Singapore's Ministry of Transport provided specialist teams from the Air Accident and Investigation Bureau and underwater locator equipment. The Malaysian government set up a rescue coordination centre at Subang and deployed three military vessels and three aircraft, including a C-130, to assist in search and rescue operations. Australia deployed a P-3 Orion to assist in the search and rescue operation. Elements of the United States Navy joined the search effort; arrived on station late on, and on.
By 5 January, 31 bodies had been recovered with the aid of the Russian and the US search teams.
Divers entered the main section of the fuselage underwater and discovered 6 bodies on 24 January.
More than ninety vessels and aircraft from Indonesia, Singapore, Malaysia, Australia, South Korea, Japan, China, the United States, and Russia participated in the search. This fleet included three ships with underwater detectors and two fuel tankers seconded to ensure efficient operation of the vessels in the search area. On the Indonesian Ministry of Transport reported that two other Indonesian tender vessels had been fitted with equipment which could detect acoustic signals from the flight recorder beacons and airframe metal, as well as multibeam side scan sonar.
The official search for bodies ended on, after 106 bodies had been recovered. 56 bodies remained unaccounted for.
A live Reddit feed that was constantly updating the details of the search and recovery efforts, leaked details of the operation. An April press conference revealed details discovered by the Basarnas rescue team divers. 115 remains were recovered. 111 of them are believed to be from 99 passengers.

Wreckage

On the day of the disappearance, a fisherman observed "a lot of debris, small and large, near Pulau Tujuh. It looked like the Air Asia colours." Another fisherman reported that, while moored on Sunday at Pulau Senggora, south of the town of Pangkalan Bun in Central Kalimantan, "Around 7 am, I heard a loud booming sound. Soon afterwards, there was haze that usually happened only during the dry season. Before the exploding sound, my friends saw a plane from above Pulau Senggaro heading towards the sea. The plane was said to be flying relatively low, but then disappeared."
The fishermen's reports, delivered after they had returned home the next day, were credited with guiding the search-and-rescue team to the vicinity of the crash. The first items of wreckage were spotted by search aircraft on in the Karimata Strait, from where the crew last contacted air traffic control, and three bodies were recovered by the warship KRI Bung Tomo.
On, Basarnas claimed that a sonar image obtained by an Indonesian naval ship appeared to show an aircraft upside down on the seabed in about of water, about from the debris found on. The head of the Search and Rescue Agency also denied the existence of any sonar images of the wreckage. He stressed that only official information from his search-and-rescue service can be considered to be reliable.
On 2015, Basarnas reported evidence of a fuel slick on the water surface in the search area, but detection of the fuselage remained unconfirmed.
At a press conference given on the morning of by Basarnas, the discovery of two large submerged objects was reported:, and a thin object. Also, the previously reported fuel slick was confirmed. A later media report mentioned four large sections of wreckage, the largest being located at. Later in the day, Basarnas announced no more bodies were found, leaving the total at 30.
On, divers found parts of the aircraft, including a section of the tail. Other sections of the tail are expected to lie nearby. On divers used an inflatable device to bring the aircraft's tail to the surface of the sea. They continued to search the sea floor within of where faint pings were heard.
The flight data recorder was recovered by Indonesian divers on at, within of part of the fuselage and tail. Later in the day, the cockpit voice recorder was located and was recovered the following day.
On, the Republic of Singapore Navy Submarine rescue vessel Swift Rescue located a large section of the fuselage with one wing attached. On, ropes around the fuselage snapped during an initial failed effort to raise the wreckage. Four bodies were recovered, taking the total recovered to 69. More bodies were thought to be inside. Rear Admiral Widodo, who is in charge of recovery operations, said that the fuselage might be too fragile to be lifted.
On salvage workers recovered a large piece of fuselage, including the wings, of the A320. Lifting balloons were used to lift the fuselage, but the first attempt failed as the balloons deflated. By March 2015, all large pieces of fuselage from the jet had been lifted from the seafloor and moved for investigative purposes.

Aftermath

AirAsia

An emergency call center was established by the airline for the families of those who were on board the aircraft, and an emergency information center was set up at Juanda International Airport to provide hourly updates as well as lodging for victims' relatives. Smaller posts were also opened at Soekarno–Hatta International Airport and Sultan Hasanuddin International Airport.
On, Indonesia AirAsia retired the flight number QZ8501, changing the designation of its Surabaya-Singapore route to QZ678. The return flight number was also changed, from QZ8502 to QZ679. The Surabaya-Singapore route by AirAsia was then terminated on 4 January 2015.
Subsequent to the 1 December 2015 NTSC report as to the causes of the crash, the airline said it had already implemented improved pilot training.

Airbus

Immediately after the NTSC report on the crash was released on 1 December 2015, the manufacturer of the A320 aircraft was not ready to provide a comment, stating in an e-mail that "Airbus has just received the final accident report. We are now carefully studying its content."

Indonesia

AirAsia did not have any official permission to fly the Surabaya–Singapore route on Sunday – the day of the crash – but was licensed on four other days of the week, and, according to an Indonesian Ministry of Transport statement, "The Indonesian authorities are suspending the company's flights on this route with immediate effect pending an investigation." In response on the same day, the Civil Aviation Authority of Singapore and the Changi Airport Group made a clarification that AirAsia QZ8501 "has been given approval at Singapore's end to operate a daily flight for the Northern Winter Season from 26 October 2014 to 28 March 2015".
On, Indonesian Ministry of Transport representative Djoko Murjatmojo stated that "officials at the airport operator in Surabaya and air traffic control agency who had allowed the flight to take off had been moved to other duties", and an immediate air transport directive had been issued "making it mandatory for pilots to go through a face-to-face briefing by an airline flight operations officer on weather conditions and other operational issues prior to every flight".
The loss of Flight 8501 also brought attention to the lack of weather radar at Indonesian air traffic control centres. According to the Toronto Star, "Indonesia’s aviation industry has been plagued with problems... pilot shortages, shoddy maintenance and poor oversight have all been blamed following a string of deadly accidents in recent years."
The West Kotawaringin administration in Pangkalan Bun, Central Kalimantan, planned to build a memorial for the Air Asia flight which also doubles as a monument for aviation safety. Central Kalimantan deputy governor Achmad Diran also stated that the monument is also going to be the symbol of gratitude and appreciation for the efforts of the National Search and Rescue Agency. The cornerstone ceremony took place on Wednesday, and was attended by local and state officials and representatives from Australia and Singapore. West Kotawaringin regent Ujang Iskandar stated that "With this monument, we hope that the families and the government will lay flowers every 28 December, and continue the dialogue on aviation safety in Indonesia." On 22 March, there was a gathering of people near the site of the crash and the crowd laid flowers around.

Family members of crew members and passengers

Air Asia has reportedly offered US$32,000 or Rp300 million to each of the grieving family members of the victims of the accident as initial compensation from an overall part of compensation, Wall Street Journal claimed from a letter on Air Asia stationery dated 2 January grieving family member David Thejakusuma received; who had 7 family members on the flight, the amount for each family member he lost.
On 16 March 2015, Monash University awarded in the form of posthumous title the Bachelor of Commerce to one of the late crash victims, Kevin Alexander Sujipto. Professor Colm Kearney, Dean of the Faculty of Business and Economics presented it to a member of his family. A memorial service was held alongside the presentation of the award, and was attended by the Consul General of Indonesia for Victoria and Tasmania, Dewi Savitri Wahab, 40 of the deceased's friends and representatives from the Indonesian Student Association in Australia Monash University branch.
On 28 December 2015, the first anniversary of the crash, a private prayer service was held in a private room in Mahameru Building, East Java Regional Police, Surabaya, and was attended by family members and relatives of the victims of the crash. The service was also attended by the Head Chief of the Search and Rescue Agency Henry Bambang Soelistyo. Representatives from the family members asked the National Transportation Safety Committee to ensure the safety of air travel in Indonesia. The Indonesian Government was also asked by the family members to ratify the Montreal Convention, finally ratified on 19 May 2017.

Legal proceedings

France opened a criminal investigation to investigate possible manslaughter charges. The family of the first officer, a French national, have filed a lawsuit against AirAsia in connection to the lack of permission to fly on that day, claiming the airline was "endangering the life of others".
Surabaya Mayor Tri Rismaharini says her administration is ready to sue AirAsia should it ignore the rights of the families of passengers on flight QZ8501, following the suspension of the airline's flight permit from the East Java city to Singapore. Risma said her administration had also consulted with legal experts from Airlangga University on the fears of most families regarding the difficulties in disbursing insurance funds, after the Transportation Ministry regarded the Surabaya-Singapore flight on Dec. 28 as illegitimate. She said her administration continued to collect data on the victims, including their valuable belongings. The data would later be used for insurance purposes and matters related to the beneficiary rights of the affected families.
A US-based aviation lawyer was planning to sue AirAsia claiming that they are "representing" 10 families over an aircraft malfunction following the crash of Flight QZ8501. Principal of Chicago-based Wisner Law Firm Floyd Wisner said that although preliminary investigations found that weather was a factor, the Airbus A320-200 suffered a malfunction of the fly-by-wire system. According to the statement, the lawsuit, which was filed in the US state of Illinois, states that "at the time the accident aircraft left the control of defendant Airbus, it was defectively and unreasonably dangerous," and names Honeywell International, Motorola Inc and other suppliers along with Airbus as defendants.
The case was Aris Siswanto et al. v Airbus, SAS et al., 1:15-cv-05486. U.S. District Court, Northern District of Illinois. On 30 June 2015, the suit had still named only Airbus and its suppliers but AirAsia was to be added as a defendant, according to Floyd Wisner of the Wisner law firm. However, on 9 December 2016, the case was dismissed and the lawsuit was dropped.

Air transport industry

Following the recovery of the flight recorders, on 12 and, an anonymous International Civil Aviation Organization representative said, "The time has come that deployable recorders are going to get a serious look." Unlike military recorders, which jettison away from an aircraft and float on the water, signalling their location to search and rescue bodies, recorders on commercial aircraft sink. A second ICAO official said that public attention had "galvanized momentum in favour of ejectable recorders on commercial aircraft".

Indonesian tourism

Indonesia's tourism was badly affected by the accident. According to the head of Indonesia's Central Statistics Agency Suryamin in a press conference at his office on 1 April 2015, the accident caused the number of foreign visitors to decline. Figures from the Indonesian Ministry of Tourism showed that the number of incoming foreign tourists at Surabaya's Juanda Airport declined by 5.33%, Jakarta's Soekarno-Hatta International Airport by 15.01%, and Bandung's Husein Sastranegara Airport by 10.66%.

Investigation

The events leading to the crash were investigated by Indonesia's National Transportation Safety Committee. Assistance was provided by Australia, France, Singapore, and Malaysia.
Data from the flight data recorder were downloaded. 124 minutes of cockpit dialogue was successfully extracted from the cockpit voice recorder. The sound of many alarms from the flight system can be heard in the final minutes, almost drowning out the voices of the pilots. The investigators ruled out a terrorist attack as the cause and then examined the possibility of human error or aircraft malfunction. The aircraft altitude recorded by ATC radar increased from between 06:17:00 and 06:17:54 WIB, at an initial rate of up to. At 06:17:54, the aircraft descended from in six seconds, and from in 25 seconds.
Although the aircraft's route took it through areas of cloud that extended from up to, FDR data showed that weather was not a factor in the accident.
Acting director of Air Transportation, Djoko Murjatmodjo, clearly stated that the investigation of the flight route and the investigation of the crash itself are separate. Murjatmodjo said that "AirAsia is clearly wrong because they didn’t fly at a time and schedule that was already determined." Both Singapore's civil aviation authority and the Changi Airport Group stated that Air Asia was allowed daily flights between Surabaya and Singapore. Tatang Kurniadi, head of Indonesia's national transportation safety committee, stated that sabotage was ruled out as a cause of the accident by the black boxes, and a preliminary report was supposedly submitted to the International Civil Aviation Organisation by early February.

Final NTSC report

After studying the wreckage of the Airbus A320-216 as well as the two black boxes and the cockpit recorder, Indonesia's National Transportation Safety Committee issued a report with their conclusions from the investigation on 1 December 2015. The report stated that the sequence of events that led to the crash started with a malfunction in two of the plane's rudder travel limiter units. A tiny soldered electrical connection in the plane's RTLU was found to be cracked, likely for over a year, causing it to intermittently send amber master caution warnings to the electronic centralised aircraft monitor —with the plane's maintenance records showing that the RTLU warning had been sent 23 times over the previous year, but was always solved by resetting the RTLU system. On this flight, the RTLU issue sent an amber caution warning four different times, and the first three times that the ECAM system gave the warning "Auto Flight Rudder Travel Limiter System", the pilot in command followed the ECAM instructions, toggling the flight augmentation computer 1 and 2 buttons on the cockpit's overhead panel to off and then on. This procedure did clear the amber master caution warnings for each of those first three warnings.
Specifics in the report indicate that French First Officer Rémi Emmanuel Plesel was at the controls just before the stall warning sounded in the cockpit indicating that the jet had lost lift. Investigators also found that, just moments earlier—on the fourth occurrence of the RTLU warning during the flight—the Captain chose to ignore the procedure advised by the ECAM instructions, and, instead, left his seat and reset the circuit breaker of the entire FAC, unintentionally disengaging multiple flight control systems, which would have to be turned on by the pilots after the circuit breakers are reset. This circuit breaker is not on the list of circuit breakers that are allowed to be reset in flight, and disabling both FACs placed the aircraft in alternate law mode, disengaging the autopilot and stopping the automatic stall protection and bank angle protection. The FAC is the part of the fly-by-wire system in A320 aircraft responsible for controlling flight surfaces including the rudder. Without the FAC's computerized flight augmentation, pilots would have to "rely on manual flying skills that are often stretched during a sudden airborne emergency". When the crew was required to fly the Airbus A320 manually, there was an unexplained nine-second delay between the start of the roll and either pilot attempting to take control. After nine seconds, the aircraft was banking at a 54° angle.
The report did not specifically conclude that pilot error caused the crash while detailing the chain of events leading to the loss of Flight 8501. However, one of the investigators, the NTSC's Nurcahyo Utomo, referred to an apparent miscommunication between the pilots and said that the malfunction should not have led to a total loss of control had they followed the recommended procedure.

Side-stick control issue

The example of miscommunication between the pilots was when the plane was in a critical stalling condition, the co-pilot misunderstood the captain's command "pull down"; instead of pushing the airplane's nose down, he pulled the stick back, which would have ordered the plane to climb more steeply. Because the captain was also pushing the stick forward and because Airbus has a dual-input system, the two stick inputs cancelled each other out, which led to the plane remaining in a stall condition until the end of the black box recording.
On 3 December 2015, Indonesia's air transportation director general, Suprasetyo, said that the National Safety Transportation Board had provided recommendations as to tightened controls on aircraft maintenance and flight crew competence. He added that the government had implemented "... a series of corrective actions as a preventive measure so that the same accident will not happen again in the future." Suprasetyo also confirmed that the suspension of Indonesia AirAsia's Surabaya–Singapore route would not be lifted until the carrier had completed the steps recommended by the KNKT.
The report stated that the crash resulted from the flight crew's inability to control the aircraft in alternate law. The cracking of a solder joint resulted in the failure of the Rudder Travel Limiter Unit four times during the flight. The flight crew action to the first three faults was in accordance with the Electronic Centralized Aircraft Monitor messages. Following the fourth fault, the Flight Augmentation Computer's circuit breakers were reset by the flight crew, resulting in electrical interruption to the computers causing the autopilot to disengage and the flight control logic to change to Alternate Law. The rudder deflected 2 degrees to the left, causing the aircraft to roll up to 54 degrees. Subsequent flight crew actions resulted in the aircraft entering a prolonged stall from which they were unable to recover.

Events leading to crash based on report

Flight 8501 took off at 05:35 WIB and reached its cruising altitude at flight level 320 four minutes later and was on a 329 degree heading.
At 05:57, the aircraft's anti-ice system was turned on at the request of first officer Plesel. The flight was normal until 06:00 when the following ECAM memo was displayed :
One minute later the single chime alarm sounded and the Master Caution light came on. The ECAM then displayed:
Captain Iriyanto read the actions for fixing this failure, saying, "FAC 1 off and on. FAC 2 off and on." The flight crew then contacted Jakarta Air Traffic Control, and requested to climb to FL 380 to avoid the weather, as well as turn 15 degrees to the left for the same reason. The controller rejected the first request due to traffic in the area though but gave permission to 15 degrees left. The flight crew acknowledged. This was the last communication from Flight 8501.
First officer Plesel then gave a cruise briefing, stating that the flight would divert to Ahmad Yani International Airport in case of an emergency arising in flight.
The same alarm sounded and the same ECAM memo displayed three more times at 06:09, 06:13, and 06:16 respectively, totaling four times all together. At 06:16, Flight 8501 was cleared to climb to FL 380 but received no response.
The flight crew took the proper actions for the first, second, and third memos. When the memo displayed for the fourth time however, captain Iriyanto, frustrated, decided to reset to the FAC circuit breakers, having previously seen this action being performed by a ground engineer, and believed that it was okay to perform this action in flight. However, resetting FAC CB's was actually prohibited in flight. Although Airbus described resetting FAC CB's in documents, it did not describe the results of what happened if the same action was performed in flight. Only pilots who had a strong understanding of the aircraft's systems knew what would happen if an FAC CB was reset in flight.
The CB's were reset, followed by several Master Cautions sounding regarding FAC's 1 and 2. The autopilot and auto throttle both disengaged from the circuit breaker reset, and the flight control law changed from Normal to Alternate. First officer Plesel only reacted nine seconds after all of these actions, likely having been distracted by them. At this time, the aircraft was banked left at 54 degrees and the roll angle was nine degrees right. Captain Iriyanto said, "level, level, level," in response to the roll. Plesel, possibly spatially disoriented due to the roll sensation, over-corrected twice: first by making a sharp right bank input and then a sharp left bank input. Plesel then made a nose-up input on his side-stick, causing the aircraft to enter a steep climb at a 24 degree nose-up pitch. At 06:16 the stall warning sounded for one second. One minute later, at 06:17:17, the stall warning sounded again and continued to sound for the remainder of the flight. At this time the angle of attack was at 40 degrees. The cockpit voice recorder also recorded an increase in background noise which also continued for the remainder of the flight. The following was recorded on the CVR:
In just 54 seconds, the aircraft climbed from FL 320 to, at which point the aircraft entered a stall, descending at a rate of per minute. Captain Iriyanto made a nose-down input on his side-stick and instructed first officer Plesel to do the same; Plesel said that he was trying, but continued to make nose-up inputs. The aircraft made one full circle as altitude was lost. At, the aircraft descent range changed to per minute. At 06:20:35 the flight data recorder stopped recording. The CVR stopped recording one second later, at 06:20:36. The aircraft crashed into the Java Sea and was destroyed. All 162 people on board were killed.

Dramatization

The crash was dramatized in the 16th season of the TV Series Mayday, in an episode entitled "Deadly Solution", aired just over two years after the crash on February 6, 2017. Also, Science Channel aired a documentary on April 28, 2015 called "AirAsia 8501: Anatomy of a Crash".