Vigo Ordnance Plant
The Vigo Ordnance Plant, also known as the Vigo Chemical Plant or simply Vigo Plant, was a United States Army facility built in 1942 to produce conventional weapons. In 1944 it was converted to produce biological agents for the U.S. bio-weapons program. The plant never produced any bio-weapons before the end of World War II but did produce 8000 pounds of an anthrax simulant. The plant was transferred to Pfizer after the war; the company operated it until announcing its closure in 2008.
Location
The Vigo Ordnance Plant was located on of a more than government-owned tract and cost $21 million to build. The facility was constructed in the Honey Creek Township in Vigo County, Indiana. The plant was located about six miles south of Terre Haute. The area surrounding the plant was flat, covered with cornfields and dotted by hog farms. The site of the former Vigo Plant is south of Interstate 70 near Highway 41 and Indiana State Highways 150 and 63.History
Construction and conversion
The U.S. Army Ordnance Corps constructed the Vigo Plant in 1942, prior to the official start of the U.S. biological weapons program. The Vigo Ordnance Plant began producing conventional explosives and munitions on February 18, 1942. The Army decommissioned the factory less than year later, and on June 30, 1943 the plant was transferred to the U.S. Army Corps of Engineers. Portions of the Vigo Plant were then leased to the Delco Radio Corporation for the manufacture of military electronics equipment. The plant served in this capacity until May 1944.On May 8, 1944 the Army Special Projects Division directed the Vigo Plant to convert its facilities for full-scale biological agent production. The plant was converted for biological warfare use by the H.K. Ferguson Construction Company; they added fermenter tanks, slurry heaters, laboratories and the other necessities of a biological warfare facility. The plant was to be the first U.S. anthrax factory and would be utilized filling a British order for anthrax bombs. In March 1944 the British had placed an order for 500,000 of these bombs which Winston Churchill, remarked, should only be considered a "first installment".
Bio-weapons production
When it was conceived, the initial plan was for the Vigo Plant to be a production facility for anthrax and botulinum toxin. The 1944 order converting the plant to a BW facility directed that it become a factory capable of producing 275,000 boutlin bombs or one million anthrax bombs per month. The core of the Vigo Plant's BW operation was the anthrax fermenters installed during the renovations in 1944. There were 12 20,000 gallon fermenter tanks at Vigo, the total of 240,000 gallons which made it the largest bacterial mass-production line anywhere in the world at the time.After U.S. BW scientists worked through the problems presented by trying to mass-produce bombs that were to be filled with a deadly biological agent, the production line was essentially ready to operate. The line would fill the British four pound anthrax bombs with an anthrax slurry and then cluster them into the M26 cluster adapter, to form the M33 cluster bomb. Before production could begin, however, safety testing commenced. The scientific director of the U.S. BW program, Ira Baldwin, selected Walter Nevius, a specialist in pathogen containment, to lead the safety inspections which began when he arrived at Vigo in the summer 1944.
Nevius was considered conscientious, so much so that at one point the Army wanted to replace him; this resulted in Baldwin resigning his position and becoming an "advisor" to the U.S. BW program. The testing regimen that followed extended well into 1945. The first tests ran water through the system, to ensure there were no leaks. A second round of tests were run with an anthrax simulant, Bacillus globigii. The plant was pronounced water-tight by Nevius in April 1945 and trial runs with the simulant began in June.
By the time the plant was ready to produce the simulant the end of World War II was on the horizon. The plant was able to produce about 8,000 pounds of B. globgii before production was halted in October 1945, but was never able to produce any BW agents, including anthrax, before the war ended. As October 1945 ended, approximately $800,000 worth of equipment at Vigo was declared surplus. Eighteen boxcars were loaded with caustics, sulfuric acid, bleach, tributyl phosphate and 765,000 explosive detonators and shipped elsewhere for storage. Vigo Ordnance plant was placed on "stand-by" in December 1945, in reality, the demilitarization process had already begun.
Demilitarization
The plant remained on standby to produce "highly classified material" and in February 1947 four areas of the plant were declared restricted. On April 30, 1947 demilitarization of the Vigo Plant began; this allowed prospective buyers to inspect the site. Even with the earlier equipment removal, the fermenters remained behind. On December 15, 1947 the Pfizer company executed a 20-year lease agreement with the government to take over the Vigo site. The company would begin antibiotic manufacture at Vigo in 1948 but the military continued to liquidate the surrounding land into 1949. That year a tract was acquired by the Bureau of Prisons to be used as agricultural land, other portions of the Vigo property were acquired by various private entities. The BW production facilities at Vigo were eventually replaced by a more modern factory at Pine Bluff Arsenal in 1954.Pfizer's ownership
After the lease agreement, and later the sale of the plant, was finalized the company transferred John E. McKeen to the Vigo site in 1948 in preparation for the production of streptomycin. The main objective of Pfizer's Vigo operation in the years after the war was the production of veterinary antibiotics. The large fermenters were used during the period after the war to produce penicillin but afterwards sat dormant for decades. Of the areas at Vigo not utilized by Pfizer, most were left undisturbed. Adjacent to the old BW buildings the company constructed their own facilities for drug manufacturing.After operating the Vigo plant since 1948 Pfizer announced in October 2007 that 600 of the plant's 750 employees would be placed on paid leave. The announcement followed disappointing sales for the plant's flagship product, an inhaled insulin known as Exubera. Beginning in 1999, Pfizer had invested $300 million in the plant and hired 400 additional employees, Pfizer's Vigo location was declared the sole producer of Exubera. In January 2008 those employees on paid leave were permanently eliminated. The company announced in May 2008 the remaining 140 jobs, occupied making antibiotics Cefobid and Unasyn, at the plant would be eliminated and the plant closed. In November 2008 the company announced the site and its buildings were for sale.