Boeing KC-97 Stratofreighter


The Boeing KC-97 Stratofreighter is a United States strategic tanker aircraft based on the Boeing C-97 Stratofreighter. It was succeeded by the Boeing KC-135 Stratotanker.

Design and development

The KC-97 Stratofreighter was an aerial refueling tanker variant of the C-97 Stratofreighter, greatly modified with all the necessary tanks, plumbing, and a flying boom. The cavernous upper deck was capable of accommodating oversize cargo accessed through a very large right-side door. In addition, transferable jet fuel was contained in tanks on the lower deck. Both decks were heated and pressurized for high altitude operations.
Note: Occasionally the KC-97 has been referred to as "Stratotanker". However, all reputable sources refer to the KC-97 as Stratofreighter, not -tanker. This includes both Boeing and the USAF themselves.

Operational history

The USAF began operating the KC-97 in 1950. It purchased a total of 811 KC-97s from Boeing, as opposed to only 74 of the C-97 cargo version. The KC-97 carried aviation gasoline for its own piston engines but it carried jet fuel for its refueling mission, this required an independent system for each type of fuel. However, it was able to offload its aviation gas to a receiver in an emergency in a procedure known as a "SAVE".
These tankers were vitally important to the world-wide Boeing B-47 Stratojet strategic operations. An example was the support of Arctic reconnaissance flights from Thule Air Base.
While it was an effective tanker, the KC-97's slow speed and low operational altitude complicated refueling operations with jet aircraft. B-52s typically lowered their flaps and rear landing gear to slow the aircraft enough to refuel from the KC-97. In addition, a typical B-52 refueling engagement profile would involve a descent that allowed the aircraft pair to maintain a higher airspeed. In the early 1960s, the Tactical Air Command added General Electric J47 two twin- jet pods from retired KB-50 aerial tankers to produce the KC-97L. These jet pods increased the speed of the KC-97 and made it more compatible with jet fighter planes like the F-84, F-100, and F-101.
In 1956, the Strategic Air Command began phasing out its KC-97s in favor of the KC-135 Stratotanker. KC-97s continued flying with Tactical Air Command, the Air Force Reserve, and the Air National Guard. The rest of the KC-97s were retired completely in 1978, when the Texas Air National Guard and the Utah Air National Guard exchanged their KC-97Ls for the C-130 Hercules and the KC-135 Stratotanker, respectively.
One KC-97 airframe was adapted into the Aero Spacelines Super Guppy, a transport plane designed specifically to support the Apollo Program by carrying Saturn IB and Saturn V upper stages across the country. The aircraft carried the Saturn S-IVB stage, which served as the second stage of the Saturn IB, the third stage of the Saturn V, and the fourth stage for the never-built Nova rocket.
This modified KC-97, constructed in 1953, was eventually purchased by NASA in 1997. It is still in service supporting NASA, other Federal agencies, and Federal contractors. It is one of two KC-97s left still in flyable condition, the other being former KC-97G 52-2718, "Angel of Deliverance", currently flown by Berlin Airlift Historical Foundation as YC-97A 45-59595.

Variants

;KC-97A: Three C-97As were converted into aerial refueling tankers with rear loading door removed and a flight refueling boom added. After the design was proven, they were converted back into the standard C-97A.
;KC-97E: aerial refueling tankers with rear loading doors permanently closed, 60 built. Some were later converted into transports as the C-97E.
;KC-97F: 3800 hp R-4360-59B engines and minor changes, 159 built. Some were later converted into transport as the C-97F.
;KC-97G: Dual-role aerial refueling tankers/cargo transportation aircraft. KC-97G models carried underwing fuel tanks. 592 built.
;EC-97G: ELINT conversion of three KC-97Gs. 53-106 was operated by the Central Intelligence Agency for covert ELINT operations in the West Berlin Air Corridor.
;C-97G: 135 KC-97Gs converted to transports.
;GKC-97G: Five KC-97Gs were used as ground instruction airframes.
;JKC-97G: One aircraft was modified to test the underwing General Electric J47-GE-23 jet engines, and was later designated KC-97L.
;HC-97G: KC-97Gs converted for search and rescue operations, 22 converted.
;KC-97H: One KC-97F was experimentally converted into a hose-and-drogue refueling aircraft.
;YC-97J: two KC-97G conversion with four 4250 kW Pratt & Whitney YT34-P-5 turboprops, dropped in favour of the Boeing KC-135 Stratotanker.
;C-97K: 27 KC-97Gs converted to troop transports.
;KC-97L: 81 KC-97Gs modified with two J47 turbojet engines on underwing pylons.

Operators

The following USAF wing organizations flew the various KC-97 models at some time during their existence:

Active duty

;27 June 1954:KC-97G AF Ser. No. 52-2654 which departed from Altus Air Force Base, Oklahoma, encountered poor weather at its destination, March Air Force Base in California, and attempted to divert to Norton Air Force Base, but crashed into Box Springs Mountain north of Riverside, California, killing all 14 people on board.
;4 May 1955:USAF KC-97G 53-0110 was flying in formation when it crashed into the Atlantic 90 mi off Iceland due to loss of control caused by an engine fire, killing all nine on board.
;6 July 1956:USAF KC-97E 51-0220 crashed in a wooded area 45 mile northeast of Goose Bay, Canada after reporting an engine fire, killing all six on board.
;22 January 1957:a KC-97G AF Ser. No. 53-0222 from Griffiss Air Force Base, New York, crashed in the foothills of the Adirondack Mountains, killing its crew of seven.
;9 May 1957:KC-97F AF Ser. No. 51-0258 en route from Sidi Slimane Air Base, Morocco, to Lajes AB, Azores, ditched in the Atlantic 550 km SE of the Azores Islands following a double engine failure. All seven crew survived. The airplane floated for ten days before being sunk by the battleship USS Wisconsin.
;18 July 1957:KC-97G AF Ser. No. 52-2737 from the 380th Air Refueling Squadron with a crew of eight, exploded and crashed into Lake Champlain at 2128 hrs., when two of the four engines failed three minutes after take-off from Plattsburgh AFB, New York. There were three survivors.
;29 October 1957:KC-97G AF Ser. No. 52-2711 of the 509th Bomb Wing, out of Walker AFB, New Mexico, crashed 35 miles north of Flagstaff, Arizona, while on a nine-hour low-level survey flight to determine minimum altitude restrictions for B-47 training routes. The aircraft was seen over Gray Mountain, Arizona, at altitude of 60 feet shortly after 0830 hrs., and then heard striking a cloud-shrouded cliff face, killing 16 crew and strewing wreckage for 200 yards along mountainside.
;22 July 1959:KC-97 AF Ser. No. 52-2703 of Pease Air Force Base crashed near Andover, New Hampshire, while on a nighttime training mission; all seven crewmen were killed.
;14 December 1959:KC-97G AF Ser. No. 53-0231 of the 384th Air Refueling Squadron, out of Westover AFB, Massachusetts, collided with a B-52 during a refueling mission at an altitude of ~15,000 feet. The aircraft lost the whole left horizontal stabilizer and elevator, the rudder, and the upper quarter of the vertical stabilizer. The crew made a no-flap, electrical power off landing at night at Dow AFB, Maine; seven crew okay. "Spokesmen at Dow Air Force, Bangor, said the B52 apparently 'crowded too close' and rammed a fuel boom into the tail of a four-engined KC95 tanker plane." Aircraft stricken as beyond economical repair. Two crew on the B-52 ejected, parachuted safely, and were recovered by helicopters in a snow-covered wilderness area. The bomber and remaining eight crew safely landed at Westover AFB.
;30 March 1960:KC-97 AF Ser. No. 51-0363 ditched and sank off Cape Canaveral. This particular aircraft was lost due to engine failure. The crash resulted in 3 fatalities of the 14 crew. The wreck of the aircraft was discovered June 6, 2015, in 365 feet of water by divers.
;15 April 1960:KC-97G AF Ser. No. 52-0919 of the 307th Air Refueling Squadron, 307th Bomb Wing, crashed on take-off from Lincoln AFB, Nebraska, after the undercarriage collapsed. All 24 on board survived, with two airmen suffering leg fractures and five others with minor cuts and burns.
;27 June 1960:KC-97G AF Ser. No. 52-2728 of the 380th Air Refueling Squadron, Plattsburgh AFB, New York, suffered failure of lubrication on an engine impeller shaft during an evening four-hour training mission to refuel a Boeing B-47 Stratojet. During rendezvous at 15,500 feet, the tanker's number one powerplant caught fire. As the bomber moved away from the burning tanker, the crew tried unsuccessfully to put out the blaze. The plane went into a spin as the wing failed outboard of the engine; the aircraft crashed on Jonathan Smith Mountain, a hill east of Puzzle Mountain in Newry, Maine. The flash of the fire was seen from as far away as Lewiston and Bridgton. All five crew were killed. Wreckage covering five acres was still there as of 2010.
; 5 November 1964:KC-97 AF Ser. No. unknown of Pease Air Force Base crashed on takeoff; all five crewmen were killed.
;19 December 1964: USAF KC-97G 52-907 ran off the runway at Ernest Harmon AFB after the pilot landed too far down the runway, killing all five on board. The pilot attempted to abort the landing, but the aircraft struck approach lights and crashed into a pond.
;19 January 1969: Wisconsin Air National Guard KC-97L 52-0904 crashed short of the runway at General Mitchell Airport, killing four of 11 on board.
;17 September 1971:KC-97G IAF Serial 4X-FPR/033 of the Israeli Air Force, was shot down by Egyptian missiles over Suez, Egypt; seven of eight-man crew were killed.

Surviving aircraft

;Airworthy
;;KC-97G Stratofreighter
;;KC-97L Stratofreighter
;On Display
;;KC-97G Stratofreighter
The KC-97 Stratofreighter is shown in both its cargo and tanker tasks in the 1955 film Strategic Air Command, refueling a B-47 in flight, and in the 1957 film Bombers B-52, refueling B-52s.

Specifications (KC-97L)

Citations